John Deere 1550 CWS CIS Combines (SN. from 060063) Operation and Test Manual (TM8243)

Table of Contents:
   Introduction
      Foreword
   Safety
      Safety Information
   Diagnostics
      AHC-Active Header Control
   Engine System
      General Information
      Test and Adjustment Procedures
      Engine Diagnostics
      Identification and Location of Components
   Cooling and Air Intake Systems
      General Information
      Test and Adjustment Procedures
      Air Intake System Diagnostic
      Engine Cooling System Diagnostic
      Identification and Location of Components
   Electrical System
      How To Use Diagnostic Information
      Electrical System Schematics
      Fuse Board
      Engine Start-Up System Diagnostic
      Battery Recharging System Diagnostic
      Engine Shut-Off System Diagnostic-(060063 - 060092)
      Engine Shut-Off System Diagnostic-(060093 - )
      Engine Speed Diagnostic-(060063 - 060092)
      Engine Speed Diagnostic-(060093 - )
      Engine Coolant Temperature Gauge Diagnostic
      Engine Oil Pressure Gauge Diagnostic
      Engine Air Filter Sensor Diagnostic
      Fuse Tester Diagnostic
      Fuel Level Gauge Diagnostic
      Straw Walker Performance Monitor and Sensor Diagnostic
      Cleaning Shoe Performance Monitor and Sensor Diagnostic
      Cab Interior Lighting Diagnostic
      Windshield Washer Motor Diagnostic
      Windshield Wiper Motor Diagnostic
      Grain Tank Lighting System Diagnostic
      Radio Diagnostic
      CB Radio Diagnostic
      Parking Brake Diagnostic
      Hydrostatic System Oil Temperature Diagnostic
      Straw Chopper Impeller Speed Sensor Diagnostic
      Tailings Elevator Auger Speed Sensor Diagnostic
      Straw Walker Crankshaft Speed Sensor Diagnostic
      Clean Grain Elevator Auger Speed Sensor Diagnostic
      Cleaning Fan Speed Sensor Diagnostic
      Hydraulic Oil Filter Sensor Diagnostic
      Grain Tank Filling Level Sensor Diagnostic
      Cigarette Lighter Diagnostic
      Compressor Diagnostic of Air Seat
      Headlights Diagnostic
      Front Clearance Lights Diagnostic
      Tail Light Diagnostic
      Left-Hand Turn Signal Diagnostic
      Right-Hand Turn Signal Light Diagnostic
      Beacon Lights Diagnostic
      Air Conditioning System Diagnostic
      Unloading Auger Lighting System Diagnostic
      Work Lights and Spot Lights On Mirror Arms Diagnostic
      Cab Auxiliary Work Light Switch Diagnostic
      Straw Chopper and Straw Walker Plugging Alarm Diagnostic
      Reel Speed Adjustment Diagnostic
      Brake Light Diagnostic
      Separator Engage Diagnostic
      Unloading Auger Engage Diagnostic
      Header Engage Diagnostic
      Feeder House Engage Reverser Diagnostic
      INFO-TRAK Monitor/ Drive Shaft Speed Monitor
      Cleaning Fan Speed Adjustment Diagnostic
      Threshing Cylinder Speed Adjustment Diagnostic
      Concave Spacing Adjustment Diagnostic
      Reel Extend/Retract Diagnostic
      Reel Raise/Lower Diagnostic
      Header Lateral Tilt Diagnostic
      Header Raise/Lower Diagnostic (Manual)
      Header Controller Board Diagnostic
      Header Lateral Tilt and Height Control Diagnostic
      Height Control Diagnostic-Rigid Cutting Platform Without Sensors
      Unloading Auger Swing Diagnostic
      Four Wheel Drive Diagnostic
      Area Counter Diagnostic
      Back-up Alarm Diagnostic-(060063 - 060092)
      Sieves and Engine Compartment Lights Diagnostic
      Header Calibration Procedures
      Connector Data
   Drive Train
      Specifications
      Checking Parts for Wear
      Hydrostatic System Test
      Transmission
   Four-Wheel Drive
      Two Speed Four-Wheel Drive
   Brakes, Steering and Rear Axle
      Brake System
      Drum Brakes
      Steering System
   Hydraulic System
      General Information
      Hydraulic Schematic
      Reel Hydraulic Motor
      Hydraulic Pump Drive
      Hydraulic Control Valve
      Hydraulic System Troubleshooting
      Identification and Location of Hydraulic Components
   Cab
      Cab and Operator`s Seat
      Air Conditioning and Heating
      Ventilation and Heating - Troubleshooting
      Operational Tests and Troubleshooting
      Air Conditioning System Operation